<object id="ivjon"><em id="ivjon"></em></object>
    <code id="ivjon"></code>
  1. <object id="ivjon"></object>
  2. <acronym id="ivjon"><label id="ivjon"><listing id="ivjon"></listing></label></acronym>

    <td id="ivjon"></td>

    阿耐思特巖田 首頁 日本語
    HOME > 新聞和活動 > 新聞內容
      新聞中心
      新聞和活動
      展會/講座信息
      網站更新信息
      新聞和活動
      重磅面向車廠,電動泵發售~
      日期: 2021-06-02

      世界超小空間

      The world’s smallest installation space (as of February 2021)

      本公司的電動BSP波紋管泵采用縱向泵結構,在電動BSP波紋管泵中實現了世界極小的安裝空間。最大限度地利用空間的優點是將設置泵的場所最小化,便于放置多臺泵。

      Anest Iwata’s bellows seal pump is a vertical type electric bellows seal pump which you can install with a smaller space than any  other similar pumps. It will allow you to make the most of the limited space; you can save some space or install multiple units in  a smaller space.

      容易抽走空氣的泵構造

      Innovative Pump Structure Easy-to-air-bleed

      由于將涂料入口設置在涂料出口的下側的泵構造,使空氣不易在泵內部的涂料路徑中積聚。因此,泵內部和涂料管路內的抽氣容易完成。

      To make the most of the nature air goes up, we designed paint inlet to be located under paint outlet. This simple but innovative  change makes air-bleed easy and fast. It usually takes few hours to release the air from paint path inside pump and pipes,  however, you will only need several minutes with this new pump.

      參數

      Specification

      使用的時候,專用的控制盤是另外必要的??梢赃M行壓力控制/頻率固定控制,手動/自動控制等各種控制管理。 

      Designated control panel is needed when  operating this pump. The panel enables to  control condition, forexample, pressure, frequency, and you can choose manual control or automatic  control.

      3組合式的高維護性

      Easy maintenance with 3 modularized units

      ①采用了防爆馬達、②泵、③框架(固定用)3個組合構成。因為是組合式,在維護的時候可以只取下必要的零件。因此,作為備用機不需要準備整套組合,只需要準備定期維護的水泵就可以放心使用。另外,除了固定用的框架以外的2個單元都附有腳輪,所以可以輕松快速地移動。

      BSP E type is composed of 3 modularized units; 1) Explosion-proof motor, 2) Pump, 3) Frame (to fix).

      For maintenance, you only need to take away the unit you want instead of disassembling the whole pump. For a backup, you do  not need the all units, just have the pump unit which is the only unit that requires periodic maintenance. The two units (except  the fixing frame) have wheels and you do not need a crane operation to move them.

      低脈動?定量吐出

      Low pulsation and stable paint output

      與泵的吐出/吸入有關的活塞動作,采用了相位偏移180度的2個等速凸輪。通過兩個等速凸輪的運動,使吐出量保持一定的同時,在吐出口始終保持吐出狀態,因此很難產生脈動。通過本公司空氣驅動密封泵的對比,得到了脈動控制在1/3以下的結果。

      BSP E type is designed to minimize pulsations with two cams that rotate at the constant velocity. Two pistons take turns of discharge  and suction to provide stable paint output with low pulsation.

      The pulsation is less than 1/3 of that of air drive bellows seal pumps.

      極限抑制顏色變化

      Minimum paint damage

      BSP密封泵是在滑動部采用BSP密封結構的活塞泵,在維持高壓力倍率和大吐出性能的同時,將對涂料的損害降到最低。因此,與同尺寸的空氣驅動泵相比實現了約7倍的涂料壽命*。(※圖表色差1.5時)

      Bellows seal pump is a piston pump with bellows which cover the rod so the paint will not touch the sliding surface. Bellows  seal pump will minimize the damage to the paint while maintaining a high flow and high pressure. You can prevent paints from  deterioration and changing its color tones. Our test results show the paint life gets about 7 times longer than that of air drive  plunger pumps when the color difference width is 1.5.

      帶有自動供油功能的驅動組合式

      Drive unit with automatic oil-feed system

            由于附帶了油泵,自動向需要定期供油的凸輪軸、線性導軌供油。驅動組合泵只需要定期檢查和更換機油,不需要麻煩的日常維護。油的檢查,可以從油量表檢查油量和狀態。

      There is no need of daily maintenance for the drive unit. Built-in oil pump will automatically feed cam-follower and linear-guide which  requires regular grease job. Please check the oil-level and its condition from the sight glass periodically, and change the oil as needed.


      年成本和年CO2排放量均減少約90%

      Reduce annual cost and CO2 emission by about 90%

             因為動力部是電機,和同等尺寸的空氣驅動泵比較,能源效率好,年度成本和CO2排放量都能減少約90%。另外,通過電動化(進站控制)更容易省電運轉,降低成本?!澞苓\轉是指在非運轉時(包括休息日)只進行循環的狀態。

      With an energy efficient electric motor, you can save  electricity cost and reduce CO2 emissions by about  90% when compared to the same size air drive  pumps. Also electric (invertor control) bellows seal  pumps make energy saving drive* easier.

      ※to drive pumps only for circulation at nonworking time

      泵的性能

      Efficiency of pumps

      本公司的電動BSP波紋管泵采用縱向泵結構,在電動BSP波紋管泵中實現了世界極小的安裝空間。最大限度地利用空間的優點是將設置泵的場所最小化,便于放置多臺泵。

      Anest Iwata’s bellows seal pump is a vertical type electric bellows seal pump which you can install with a smaller space than any  other similar pumps. It will allow you to make the most of the limited space; you can save some space or install multiple units in  a smaller space.

       

      個人信息保護方針
      網站使用條款
      網站地圖
      Copyright ? 2015 ANEST IWATA Corporation, All Rights Reserved. 備案號:滬ICP備07501439號
      免费H网站在线观看的